Cummins ISX11.9 CM2250 (2010-12) Fault Code: 1659 PID: SPN: 1328 FMI: 31 Engine Misfire Cylinder 6- Condition Exists - EcuForce Truck (2024)

Table of Contents
Related Related products

Shop

Account

Cart$0.00

Subtotal: $0.00

No products in the cart.

Circuit Description
An algorithm in the ECM calibration monitors engine speed as each injector fires while the engine is at idle. If a cylinder has high or low contribution to engine speed, this fault will become active. The intention of this fault is to assist in troubleshooting performance complaints such as engine misfire and low power.

Component Location
The ECM is located on the intake side of the engine.

Conditions for Running the Diagnostics
This diagnostic runs continuously when the engine coolant temperature is greater than 71?C [160?F].

Conditions for Setting the Fault Codes
If cylinder 6 has high or low contribution to engine speed, this fault will become active.

Action Taken When the Fault Code is Active
The ECM illuminates the amber CHECK ENGINE lamp and/or the Malfunction Indicator Lamp (MIL) immediately when the diagnostic runs and fails.

Conditions for Clearing the Fault Code
To validate the repair, start the engine and let it idle for up to 5 minutes.
The fault code status displayed by INSITE? electronic service tool will change to INACTIVE immediately after the diagnostic runs and passes.
The ECM will turn off the amber CHECK ENGINE lamp after the diagnostic runs and passes.
For On-Board Diagnostic (OBD) engines, the ECM will turn off the MIL after three consecutive trips where the diagnostic runs and passes.
The ?Reset All Faults? command in INSITE? electronic service tool can be used to clear active and inactive faults, as well as extinguish the MIL for OBD applications.

Shop Talk
If Fault Code 1659 is inactive in the ECM memory and there is no complaint such as ?low power? or ?engine misfire?, it is possible that an intermittent event, such as air entering the fuel system, following a filter change caused the fault. Inactive counts of Fault Code 1659 should be disregarded unless other performance symptoms are present. The engine coolant temperature must be greater than 71?C [160?F] before this diagnostic will run.

Causes of cylinder misfire can include:

Valve lash out of specification (compare actual valve lash to reset limits)
Cylinder malfunction (check for high blowby when the engine is loaded)
Valve malfunction or valve held open (listen for intake valve ?chirping? noise in the intake)
Cylinder head or gasket malfunction (look for signs of oil, coolant, or casting flash in the intake or exhaust passages)
Extreme camshaft wear (inspect the camshaft lobes for wear)
Extra, missing, or damaged sealing washer under an injector
Injector malfunctions (?swap? injectors to see if the problem ?follows? the indicated injector).
Check air compressor timing (if engine has had fault since new or has had a recent air compressor replacement).

Possible Cause:
1) Cylinder Misfire failure
2) ECM calibration

Related

Wiring Diagrams

Component Locators

  • Wabco PIN Code Calculator Diagnostic Software PIN 1 PIN 2

    Trucks software$10.00

    Rated 0 out of 5

  • CATERPILLAR FLASH FILE 2021 74 GB ( Collection 2021 ) sofware trucks

    CAT$55.00

    Rated 0 out of 5

  • Isuzu E-IDSS Diagnostic Service System 04.2022 ( 1 PC )

    ISUZU$126.00

    Rated 0 out of 5

  • CAT$200.00

    Rated 0 out of 5

  • CUMMINnSsg INSITEr 8.7.0.86 PRO + ZAP-IT

    cummisznn$70.00

    Rated 0 out of 5

  • Volvo Premium Tech Tool PTT 2.8.130 Diagnostic Software 04.2022 ACPI ( 1 PC )

    Trucks software$143.00

    Rated 0 out of 5

  • Detroit Diesel Diagnostic Link DDDL 8.0 PRO PROFESSIONAL Software trucks

    Detroit$25.00

    Rated 0 out of 5

  • JOHN DEERE SERVICE ADVISOR 5.3.225 DATABASE AG + CF ENGLISH 2023

    John Deere$250.00

    Rated 0 out of 5

  • John Deere$120.00

    Rated 0 out of 5

  • Bobcat Service Library [03.2019] Service, Operator, Maintenance, Bulletines, etc full update

    Bobcat$110.00

    Rated 0 out of 5

  • Detroit Diesel Diagnostic Link DDDL 6.50 ( software trucks )

    Detroit$20.00

    Rated 0 out of 5

  • Detroit Diesel Switcher Tool + Video Manual

    Detroit$12.00

    Rated 0 out of 5

  • Isuzu E-IDSS Diagnostic Service System 04.2022 ( 1 PC )

    ISUZU$126.00

    Rated 0 out of 5

  • Perkins SPI2 2018A Dealer Parts and Service

    Perkins$50.00

    Rated 0 out of 5

  • Detroit Diagnostic Link (DDDL 8.09) Engineering level 10

    Detroit$40.00

    Rated 0 out of 5

  • Noregon JPRO Commercial Fleet Diagnostics 2017 v3

    JPRO$35.00

    Rated 0 out of 5

  • Volvo Penta EPC 6 Offline VMware [12.2021] VMware

    Trucks software$64.00

    Rated 0 out of 5

  • CLAAS WebTIC Offline [11.2021] Service Information – ENGLISH Language

    CLAAS$100.00

    Rated 0 out of 5

  • Navkal 2018 offline version remove DPF MAXXFORCE 13 EPA 10

    Navistar$80.00

    Rated 0 out of 5

  • volvo Devtool Studio V2 / V3 / V4 Developer tool plus 2.6 / 2.7

    Trucks software$35.00

    Rated 0 out of 5

Related products

  • 1000 & 2000 Gen 4$50.00

    Rated 0 out of 5

  • 1000 & 2000 Gen 4$50.00

    Rated 0 out of 5

  • 1000 & 2000 Gen 4$50.00

    Rated 0 out of 5

  • 1000 & 2000 Gen 4$50.00

    Rated 0 out of 5

  • 1000 & 2000 Gen 4$50.00

    Rated 0 out of 5

  • 1000 & 2000 Gen 4$50.00

    Rated 0 out of 5

  • 1000 & 2000 Gen 4$50.00

    Rated 0 out of 5

  • 1000 & 2000 Gen 4$50.00

    Rated 0 out of 5

  • 1000 & 2000 Gen 4$50.00

    Rated 0 out of 5

  • 1000 & 2000 Gen 4$50.00

    Rated 0 out of 5

  • 1000 & 2000 Gen 4$50.00

    Rated 0 out of 5

  • 1000 & 2000 Gen 4$50.00

    Rated 0 out of 5

  • 1000 & 2000 Gen 4$50.00

    Rated 0 out of 5

  • 1000 & 2000 Gen 4$50.00

    Rated 0 out of 5

  • 1000 & 2000 Gen 4$50.00

    Rated 0 out of 5

  • FUSO$40.00

    Rated 0 out of 5

  • SERVICE MANUAL BOBCAT 1600 sms

    BOBCAT$30.00

    Rated 0 out of 5

  • FUSO$28.00

    Rated 0 out of 5

  • SERVICE MANUAL DETROIT DIESEL 16V2000 Workshop Manual M020155

    DETROIT$28.00

    Rated 0 out of 5

  • MANUAL SERVICE DEUTZ AGROTRON 80-90-100-105

    DEUTZ$34.00

    Rated 0 out of 5

  • SERVICE MANUAL HINO FD.FE.FF.SG 2019

    HINO$40.00

    Rated 0 out of 5

  • INTERNATIONAL ENGINES$31.00

    Rated 0 out of 5

  • SERVICE MANUAL BOBCAT 450 453 sms

    BOBCAT$50.00

    Rated 0 out of 5

  • SERVICE MANUAL Eaton Fuller – Autoshift 16 Service Manual (T20891)

    EATON$27.00

    Rated 0 out of 5

  • SERVICE MANUAL HINO FD.FE.FF.SG 2005

    HINO$37.00

    Rated 0 out of 5

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 1659 PID: SPN: 1328 FMI: 31 Engine Misfire Cylinder 6- Condition Exists - EcuForce Truck (2024)
Top Articles
Latest Posts
Article information

Author: Fredrick Kertzmann

Last Updated:

Views: 5713

Rating: 4.6 / 5 (66 voted)

Reviews: 81% of readers found this page helpful

Author information

Name: Fredrick Kertzmann

Birthday: 2000-04-29

Address: Apt. 203 613 Huels Gateway, Ralphtown, LA 40204

Phone: +2135150832870

Job: Regional Design Producer

Hobby: Nordic skating, Lacemaking, Mountain biking, Rowing, Gardening, Water sports, role-playing games

Introduction: My name is Fredrick Kertzmann, I am a gleaming, encouraging, inexpensive, thankful, tender, quaint, precious person who loves writing and wants to share my knowledge and understanding with you.